Abstract
The present paper is focused on the microstructural stability of the Framatome-ANP M5™ (Zr-1%NbO) alloy. Thin foils were cut from M5 cladding tubes irradiated from 1 to 6 annual cycles in EDF PWRs, and examined by analytical transmission electron microscopy (TEM). The results show that within the wide range of irradiation conditions investigated, the initial β-Nb particles undergo no amorphisation and only minor evolutions in size distribution, number density, and composition. Finally, very few c component basal loops were detected, so that no sign of accelerated growth regime has to be feared for the fuel burn-ups currently considered (∼70 GWd/t) for PWRs.
In the second part of this paper, other industrial or experimental alloys (Zy-4, M4, Zr-2.5%Nb, ZrNbSnFe) are considered to improve our knowledge about the irradiation-induced evolution of β-Nb and other minor SPP. Thin foils were cut from specimens irradiated in PWRs or MTRs (OSIRIS, SILOE) and also examined by transmission electron microscopy. In addition, Small Angle Neutron Scattering (SANS) was used to provide quantitative and statistical information on the radiation-enhanced precipitation of β-Nb needles and possible other defects or solute clusters. All these results allow a general discussion of evolution of SPP with regard to their initial structure and composition, and of the noteworthy irradiation stability of the M5™ up to high neutron fluence with respect to other alloys.
Issue Section:
Research Papers
References
1.
Mardon
, J. P.
, Garner
, G.
, Beslu
, P.
, and Charquet
, D.
, “Update on the Development of Advanced Zirconium Alloys for PWR Fuel Rod Claddings
,” ANS Portland, 2–6 March 1997, pp. 405
-412
.2.
Mardon
, J. P.
, et al, “Optimization of PWR Behaviour of Stress-Relieved Zircaloy-4 Cladding Tubes by Upgrading the Manufacturing and Inspection Process
,” Zirconium in the Nuclear Industry: Tenth International Symposium
, ASTM STP 1245, A. M.
Garde
and E. R.
Bradley
, Eds., ASTM International
, West Conshohocken, PA
, 1994
, pp. 329
-348
.3.
Ravier
, G.
, et al, “Framatome and FCF Recent Operating Experience and Advanced Features to Increase Performance Reliability
,” ANS Portland, 2–6 March 1997, pp. 31
-38
.4.
Gilbon
, D.
and Simonot
, C.
, “Effect of Irradiation on the Microstructure of Zircaloy-4
,” Zirconium in the Nuclear Industry: Tenth International Symposium
, ASTM STP 1245, A. M.
Garde
and E. R.
Bradley
, Eds., ASTM International
, West Conshohocken, PA
, 1994
, pp. 521
-548
.5.
Gilbon
, D.
, Soniak
, A.
, Doriot
, S.
, and Mardon
, J. P.
, “Irradiation Creep and Growth Behaviour, and Microstructural Evolution of Advanced Zr-Base Alloys
,” Zirconium in the Nuclear Industry: Twelfth International Symposium
, ASTM STP 1354, G. P.
Sabol
and G. D.
Moan
, Eds., ASTM International
, West Conshohocken, PA
, 2000
, pp. 51
-73
.6.
Shishov
, V. N.
, Nikulina
, A. V.
, Markelov
, V. A.
, Peregud
, M. M.
, Kozlov
, A. V.
, Averin
, S. A.
, et al, “Influence of Neutron Irradiation and Dislocation Structure and Phase Composition of Zr-Base Alloys
,” Zirconium in the Nuclear Industry: Seventh International Symposium
, ASTM STP 939, R. B.
Adamson
and L. F. P.
Van Swam
, Eds., ASTM International
, West Conshohocken, PA
, 1987
, pp. 603
-622
.7.
Toffolon
, C.
, Brachet
, J. C.
, Servant
, C.
, Legras
, L.
, Charquet
, D.
, Barberis
, P.
, et al, “Experimental Study and Preliminary Thermodynamic Calculations of the Pseudo-Ternary Zr-Nb-Fe-(O,Sn) System
,” Zirconium in the Nuclear Industry: Thirteenth International Symposium
, ASTM STP 1423, G. D.
Moan
and P.
Rudling
, Eds., ASTM International
, West Conshohochen, PA
, 2002
, pp. 361
-383
.8.
Garzarolli
, F.
, Dewes
, P.
, Maussner
, G.
, and Basso
, H. H.
, “Effects of High Neutron Fluence on Microstructure and Growth of Zircaloy-4
,” Zirconium in the Nuclear Industry: Eighth International Symposium
, ASTM STP 1023, ASTM International
, West Conshohocken, PA
, 1989
, pp. 641
-657
.9.
M. H.
Mathon
, C. H.
de Novion
, “De l'intensité à la structure des matériaux
,” J. de Physique IV (France)
, Vol. 9
, 1999
, p. 127.10.
“
Equipements expérimentaux
,” Ed. Laboratoire Léon Brillouin, CEA Saclay
, 91191 Gifsur-Yvette, France
, 1995
, p. 67.11.
J. P.
Cotton
, in: Neutron, X-Ray and Light Scattering: Introduction for an Investigative Tool for Colloidal and Polymeric Systems
, P.
Lindner
and Th.
Zemb
, Eds., North Holland Delta Series, Amsterdam
, 1991
, p. 19.12.
Griffiths
, M.
, Mecke
, J. F.
, and Winegar
, J. E.
, “Evolution of Microstructure in Zirconium Alloys During Irradiation
,” Zirconium in the Nuclear Industry: Seventh International Symposium
, ASTM STP 939
, R. B.
Adamson
and L. F. P.
Van Swam
, Eds., ASTM International
, West Conshohocken, PA
, 1987
, pp. 580
-602
.13.
Parker
, J. D.
, Perovic
, V.
, Leger
, M.
, and Fleck
, R. G.
, “Microstructural Effects on the Irradiation Growth of Zr-2,5Nb
,” Zirconium in the Nuclear Industry: Seventh International Symposium
, ASTM STP 939, R. B.
Adamson
and L. F. P.
Van Swam
, Eds., ASTM International
, West Conshohocken, PA
, 1987
, pp. 86
-100
.14.
Nikulina
, A. V.
, Shishov
, V. N.
, Peregud
, M. M.
, Tselischev
, Shamardin
, V. K.
, and Kobylyansky
, G. P.
, “Irradiation Induced Growth and Microstructure Evolution of Zr-1.2 Sn-1 Nb — 0.4 Fe Under Neutron Irradiation to High Doses
,” Effect of Radiation on Materials: 18th International Symposium
, ASTM STP 1295, R. K.
Nanstad
, M. L.
Hamilton
, F. A.
Garner
, and A. S.
Kumar
, Eds., ASTM International
, West Conshohocken, PA
, 1999
, pp. 1045
-1061
.15.
Coleman
, C. E.
, Gilbert
, R. W.
, Carpenter
, G. J. C.
, and Weatherly
, G. C.
, “Precipitation in Zr-2.5 wt% Nb During Neutron Irradiation
,” Phase Stability During Irradiation Symposium
, Pittsburgh, Oct 5–9, 1980, The Metallurgical Society of AIME
, 1981
, pp. 587
-599
.16.
Perovic
, V.
, Perovic
, A.
, Weatherly
, G. C.
, Brown
, L. M.
, Purdy
, G. R.
, Fleck
, R. G.
, et al, “Microstructural and Microchemical Studies of Zr-2.5 Nb Pressure Tube Alloy
,” Journal of Nuclear Materials
0022-3115, Vol. 205
, 1993
, pp. 251
-257
.17.
Brebec
, G.
, “Diffusion and Precipitation under Irradiation
,” A. L.
Laskar
, et al., Eds., Diffusion in Materials
, Kluwer Academic Publisher
, printed in the Netherlands, 1990
, pp. 336
-339
.18.
Sarce
, A.
, “Stability of Precipitates in the Anisotropic α-Zr Matrix under Irradiation
,” Journal of Nuclear Materials
0022-3115, Vol. 185
, 1991
, pp. 214
-223
.19.
Turkin
, A. A.
, Buts
, A. V.
, and Bakai
, A. S.
, “Construction of Radiation-Modified Phase Diagrams under Cascade-Producing Irradiation
,” Journal of Nuclear Materials
0022-3115, Vol. 305
, 2002
, pp. 134
-152
.20.
Averin
, S., A.
, Panchenko
, V., L.
, Kozlov
, A., V.
, Sinelnikov
, L., P.
, Shishov
, V., N.
and Nikulina
, A., V.
, “Evolution of Dislocation and Precipitate Structure in Zr Alloys Under Long-Term Irradiation
,” Zirconium in the Nuclear Industry: Twelfth International Symposium
, ASTM STP 1354, G. P.
Sabol
and G. D.
Moan
, Eds., ASTM International
, West Conshohocken, PA
, 2000
, pp. 105
-121
.21.
Simonot
, C.
, “Microstructural Evolution of Zirconium Alloys under Irradiation. Link with the Irradiation Growth Phenomenon
,” thesis of Paris XI University
, Orsay, France, 1995
, réf. CEA-R -5718.22.
Griffiths
, M.
, “A Review of Microstructure Evolution in Zirconium During Irradiation
,” Journal of Nuclear Materials
0022-3115, Vol. 159
, 1988
, pp. 190
-218
.23.
Griffiths
, M.
, Gilbert
, W.
, and Carpentier
, G. Y. C.
, “Phase Instability, Decomposition and Redistribution of Intermetallic Precipitates in Zircaloy-2 and -4 During Neutron Irradiation
,” Journal of Nuclear Materials
0022-3115, Vol. 150
, 1987
, pp. 53
-66
.24.
Garzarolli
, F.
, Goll
, W.
, Seibol
, A.
, and Ray
, I.
, “Effect of In-PWR Irradiation on Size, Structure, and Composition of Intermetallic Precipitates of Zr Alloys
,” Zirconium in the Nuclear Industry: Eleventh International Symposium
, ASTM STP 1295, E. R.
Bradley
and G. P.
Sabol
, Eds., ASTM International
, West Conshohocken, PA
, 1996
, pp. 541
-556
.25.
Motta
, A. T.
and Lemaignan
, C.
, “A Ballistic Mixing Model for the Amorphisation of Precipitates in Zircaloy under Neutron Irradiation
,” Journal of Nuclear Materials
0022-3115, Vol. 195
, 1992
, pp. 277
-285
.26.
Naik
, M. C.
and Argarwala
, R. P.
, “Self and Impurity Diffusion in Alpha-Zirconium
,” Acta. Metallography
, Vol. 15
, 1967
, pp. 1521
-1525
.27.
Hood
, G., M.
, “Point Defect Diffusion in a-Zr
,” Journal of Nuclear Materials
0022-3115 https://doi.org/10.1016/0022-3115(88)90091-8, Vol. 159
, 1988
, pp. 149
-175
.28.
Villars
, P.
, Calvert
, R., P.
, “Pearson's Handbook of Crystallographic Data for Intermetallic Phases
,” American Society for Metals
, Vol. 2
, 1986
.29.
de Carlan
, Y.
, Regnard
, C.
, Griffiths
, M.
, Gilbon
, D.
, and Lemaignan
, C.
, “Influence of Iron in the Nucleation of <c> Component Dislocation Loops in Irradiated Zircaloy-4
,” Zirconium in the Nuclear Industry: Eleventh International Symposium
, ASTM STP 1295, E. R.
Bradley
and G. P.
Sabol
, Eds., ASTM International
, West Conshohocken, PA
, 1996
, pp. 638
-653
.30.
Griffiths
, M.
, Gilbon
, D.
, Regnard
, C.
, and Lemaignan
, C.
, “HVEM Study of the Effect of Alloying Elements and Impurities on Radiation Damage in Zr-Alloys
,” Journal of Nuclear Materials
0022-3115, Vol. 205
, 1993
, pp. 273
-283
.
This content is only available via PDF.
All rights reserved. This material may not be reproduced or copied, in whole or in part, in any printed, mechanical, electronic, film, or other distribution and storage media, without the written consent of ASTM International.
You do not currently have access to this content.
